Журнал нано- та електронної фізики (Journal of nano- and electronic physics)
Permanent URI for this collectionhttps://devessuir.sumdu.edu.ua/handle/123456789/197
Browse
3 results
Search Results
Item Regularity of Formation of Vacuum-arc Nitride Coating Based on Multi-component Alloys(Sumy State University, 2017) Beresnev, V.M.; Шабельник, Юрій Михайлович; Шабельник, Юрий Михайлович; Shabelnyk, Yurii Mykhailovych; Шумакова, Наталія Іванівна; Шумакова, Наталия Ивановна; Shumakova, Nataliia Ivanivna; Nyemchenko, U.S.; Klymenko, S.А.; Manokhin, А.S.The physical factors, which influence on structural state and phase composition of nitride coatings based on multicomponent alloys obtained by means of vacuum-arc deposition method have been determined. It was shown that the increase in partial pressure of nitrogen ensures the formation of a single phase solid solution with fcc crystal lattice. Under the pressure of nitrogen atmosphere below 10 – 3 Pa, a single phase solid solution with a bcclattice is formed; and within the pressure of nitrogen PN = 10– 3 - 8 × 10– 22 Pa, a two-phase system of solid solutions with bcc and fcc lattices is observed. With an offset potential of – 70 V, a texture [100] is observed; and within the alteration of bias potential of (– 70 V - – 90 V) texture [100] + [111] appears. In the range of Ub from – 120 V to – 150 V, a texture [111] is observed, and, with an increase of bias potential, a texture [111] + [110] is observed.Item Structure and Properties of Vacuum Arc Single-Layer and Multiperiod Two-Layer Nitride Coatings Based on Ti(Al):Si Layers(Sumy State University, 2017) Beresnev, V.M.; Sobol, O.V.; Погребняк, Олександр Дмитрович; Погребняк, Александр Дмитриевич; Pohrebniak, Oleksandr Dmytrovych; Lytovchenko, S.V.; Stolbovoy, V.A.; Srebniuk, P.A.; Novikov, V.Ju.; Doshchechkina, I.V.; Meylehov, A.A.; Postelnyk, A.A.; Nyemchenko, U.S.; Mazylin, B.A.; Kruhlova, V.V.The paper provides an analysis of impact of deposition conditions on structural and phase state and thermal stability of vacuum arc coatings based on Ti(Al):Si layers. We studied single-phase single-layer coatings, and multiperiod bilayer coatings with second phase nitride interlayers of one of the following three metals: Mo, Cr or Zr. It was established that hexagonal and cubic lattices may form in the coatings when transition to the cubic lattice occurs with Al content of about 25 at. %. Presence of second nanoscale (7-8 nm) layers in bilayer multiperiod compositions, which consist of one nitride from CrNx, MoNx or ZrNx group, does not change the type of lattice in [Ti(Al):Si]Nx layers. Also, an fcc lattice with a strong or weak texture [111] forms in CrNx and ZrNx layers, while crystallites with hexagonal lattice form in MoNx layers. High-temperature annealing at 700 °С during 40 minutes leads to a significant (by 23 % or up to Нµ = 47.56 GPa) increase in microhardness of coating of the [Ti(Al)]Nx/ZrNy system due to formation of a nano-size structure with an average size of crystallites of 3.6 nm in [Ti(Al)]Nx layers, and 6.3 nm in ZrNx layers.Item Мультифрактальное исследование микрогеометрии поверхности (Ti-Hf-Zr-V-Nb)N нитридных покрытий(Сумский государственный университет, 2014) Погребняк, Олександр Дмитрович; Погребняк, Александр Дмитриевич; Pohrebniak, Oleksandr Dmytrovych; Борисюк, Вадим Миколайович; Борисюк, Вадим Николаевич; Borysiuk, Vadym Mykolaiovych; Багдасарян, Артем Анатолійович; Багдасарян, Артем Анатольевич; Bahdasarian, Artem Anatoliiovych; Максакова, О.В.; Смирнова, Е.В.Проведено якісне дослідження морфології (Ti-Hf-Zr-V-Nb) N нітридних покриттів залежно від по- тенціалу зсуву підкладки. Для кількісного аналізу зміни мікроскопічних неоднорідностей використо- вувався двовимірний мультифрактальний флуктуаційний аналіз. Розрахунок статистичних парамет- рів (узагальнений показник Херста та мультифрактальний спектр) вказує на відповідність теоретич- них розрахунків і експериментальних досліджень, а саме згладжування поверхні покриття із збіль- шенням енергії іонів.